Minor Service

· Replace engine oil & engine oil filter
· Inspect brake fluid level & colour 
· Check power steering fluid level 
· Check windscreen washer Ievel

 

http://www.steves.co.za/images/0GD.gif

 

· Check coolant level & concentration
· Check tyre pressures 
· Check all lights & hooter operation

Intermediate Service

· Inspect vehicle for scratches and other damages
· Inspect all warning lights on dash 
· Check all lights 
· Check hooter, wiper operation & condition of blades 
· Check brake & clutch pedal for squeaks & adjustment 
· Check for obstructions in the radiator 
· Lubricate all latches, hinges & locks
· Rectify Window washer fluid
· Load test battery and check acid concentration
· Check & rectify hydraulic fluid levels
· Pressure test cooling system levels and leaks 
· Inspect & adjust fan belts 
· Replace all filters 
· Inspect accelerator pedal for full throttle position
· Inspect timing belt & tension
· Inspect brakes & handbrake operation 
· Grease all nipples
· Replace sump plug washer and tighten sump plug
· Check for visible oil leaks
· Check all tyre pressures
· Check aircon for operation / cooling
· Check gearbox for oil leaks and correct level
· Check diff level & side shaft oil leaks
· Re-check new engine oil & coolant levels after service 
· Road test

Major Service

· Inspect vehicle for dents, scratches etc.
· Check all warning lights on dash
· Check instument cluster operation (speedo, rev counter, oil temp/pressure & cooolant temp)
· Check hooter & windscreen wipers condition
· Refill window washer bottles
· Accelerator pedal checked for full throttle 
· Report on condition of brake discs and brake pads
· Report on condition of brake shoes and brake drums
· Inspect all brake hydraulics for leaks 
· Check mechanical advance on distributor
· Replace points & condenser if necc. 
· Report on condition of cam belt / timing chain 
· Replace Fuel filter 
· Replace engine oil filter 
· Check clutch & brake pedal travel & squeeking 
· Check door lock & hinge operation 
· Check boot lock & hinge operation 
· Check bonnet lock & hinge operation 
· Grease all latches
· All locks & latches serviced 
· Check Pedal rubbers
· Load test battery & check battery acid concentration
· Check Battery terminals condition & spray protecting terminal spray 
· Refill hydraulic levels if neccesary 
· Pressure test coolant system for leaks & rectify levels 
· Inspect shocks, ball joints, lower /upper control arms bushes etc.
· Inspect all cable routing under vehicle 
· Check and rectify gearbox oil levles
· Lubricate gearbox linkages
· Check and rectify diff oil levels 
· Visually inspect exhaust system for leaks and/or corrosion
· Check adjust / re-pack wheel bearings as required 
· Inspect condition of all tyres and report 
· Check & report on aircon operation / cooling
· Adjust ignition timing (if applicable)
· Adjust idle co's (if applicable)

 

http://www.steves.co.za/images/0GD.gif

 

 
· Check windshield washers front and rear
· Check all exterior,  interior & console lights
· Check brake & clutch pedal travel for "free-play"
· Inspect & Adjust handbrake
· Brake fluid condition / colour checked 
· Rectify coollant level
· Check anti freeze concentration 
· Check for obstructions in radiator
· Check fan belt tension
· Check fan belt condition
· Compression test (if required)
· Replace spark plugs 
· Inspect spark plug wires
· Inspect supressor coils & routing 
· Replace air filter 
· Inspect cambelt tension & condition
· Inspect and rectify camtiming (if required)
· Report on condition of tappets
· Inspect CV Joint dust boots
· Check Steering wheel for alignment
· Check aircon operation / cooling
· Set iming & carb Adjusted (if applicable)
· Check Spare wheel & tools 
· Inspect & grease universal joints 
· Inspect tie rod ends 
· Inspect steering components
· Check steering rack boots 
· All grease nipples serviced  
· Torgue wheel nuts 
· Pump all tyres to specification 
· Fill engine oil
· Wash vehicle